Hollow-Fiber Membrane Contactor for Biogas Recovery from Real Anaerobic Membrane Bioreactor Permeate.

This study demonstrates the application of hollow-fiber membrane contactors (HFMCs) for the recovery of biogas from the ultrafiltration permeate of an anaerobic membrane bioreactor (AnMBR) and synthetic effluents of pure and mixed CH 4 and CO 2 . The developed membrane degassing setup was coupled with a pilot-scale AnMBR fed with synthetic domestic effluent working at 25 °C. The membrane degassing unit was able to recover 93% of the total dissolved CH 4 and 83% of the dissolved CO 2 in the first two hours of permeate recirculation. The initial recovery rates were very high (0.21 mg CH 4 L -1 min -1 and 8.43 mg CO 2 L -1 min -1 ) and the membrane was able to achieve a degassing efficiency of 95.7% for CH 4 and 76.2% for CO 2 , at a gas to liquid ratio of 1. A higher mass transfer coefficient of CH 4 was found in all experimental and theoretical evaluations compared to CO 2 . This could also be confirmed from the higher transmembrane mass transport resistance to CO 2 rather than CH 4 found in this work. A strong dependency of the selective gas transport on the gas and liquid side hydrodynamics was observed. An increase in the liquid flow rate and gas flow rate favored CH 4 transport and CO 2 transport, respectively, over each component. The results confirmed the effectiveness of the collective AnMBR and membrane degassing setup for biogas recovery. Still, additional work is required to improve the membrane contactor's performance for biogas recovery during long-term operation.